Re-Refined Oil Products And Hazardous Waste Disposal California Trusts From Evergreen Oil - msds

By: Evergreen Oil  09-12-2011
Keywords: Oil, Lubricating Oil

Evergreen Base Oils

 MSDS for 110 NEUTRAL BASE OIL

MATERIAL SAFETY DATA SHEET
EVERGREEN OIL, INC
6880 SMITH AVE
NEWARK, CA. 94560
(510) 795-4400                
  EMERGENCY - TRANSPORTATION: CHEMTREC (800) 424-9300
EMERGENCY - HEALTH: 911  
SUBSTANCE IDENTIFICATION
IDENTITY: 110 NEUTRAL BASE OIL; 110 NEUTRAL OIL
CAS NUMBER: 64742-58-1
SYNONYM / TRADE NAMES: NEUTRAL OIL; HVI PARAFFINIC, PETROLEUM OIL,
FAMILY / CHEMICAL NAME: RE-REFINED, HYDROTREATED HYDROCARBON, PETROLEUM; RE-REFINED, LUBRICATING OIL
NFPF RATINGS (SCALE 0-4): O-HEALTH, 1-FIRE, 0-REACTIVITY
MSDS FORM NO.: 100MSDS.DOC992
HAZARDOUS INGREDIENTS
THIS PRODUCT FITS THE ACGIH DEFINITION FOR MINERAL OIL MIST.PETROLEUM HYDROCARBON - AS MISTPERCENT: 100
EXPOSURE LIMITS IN AIR
OSHA PEL TWA 5 MG/M3
OSHA PEL STEL NONE ESTABLISHED
ACGIH TLV TWA 5 MG/M3
ACGIH TLV STEL 10 MG/M3
CAL OSHA TWA 5 MG/M3
PHYSICAL PROPERTIES
VAPOR DENSITY:   >1 ( AIR = 1) MELTING PT.: NOT APPLICABLE
BOILING POINT: ABOVE 600 В°F (316 В°C)
SOLUBILITY IN WATER: INSOLUBLE EVAPORATION RATE: 0.001 (ETHER=1)
% VOLATILE: NEGLIGIBLE
DENSITY: 7.1 LBS/GAL PH: NOT APPLICABLE
COEFFICIENT OF WATER/OIL DIST.: NA. POUR PT: -15 F
'MOLECULAR WEIGHT: >400
HOW TO DETECT THIS SUBSTANCE : VISCOUS, OILY, AMBER COLORED LIQUID, WITH A CHARACTERISTIC PETROLEUM ODOR AND SLIPPERY FEEL.
FIRE AND EXPLOSION DATA
FLASH PT: >360 В°F (182 В°C) COC AUTOIGNITION TEMP: NA.
LOWER FLAMMABLE LIMIT: 1 VOL. % (MIST) UPPER FLAMMABLE LIMIT: 10 VOL. % (MIST)
EXTINGUISHING MEDIA: CARBON DIOXIDE, FOAM, DRY CHEMICAL

HAZARDOUS COMBUSTION PRODUCTS
THERMAL DECOMPOSITION AND BURNING MAY PRODUCE THE FOLLOWING HAZARDOUS DECOMPOSITION PRODUCTS: CARBON MONOXIDE, HYDROGEN SULFIDE, NITROGEN OXIDES, AND OTHER TOXIC MATERIALS.
UNUSUAL FIRE AND EXPLOSION HAZARDSMOVE CONTAINER FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK. APPLY COOLING WATER TO SIDES OF CONTAINERS THAT ARE EXPOSED TO FLAMES UNTIL WELL AFTER FIRE IS OUT. STAY AWAY FROM ENDS OF TANKS AND DRUMS - HEATED CONTAINERS MAY RUPTURE, EXPLODE OR BE THROWN INTO THE AIR. HEATED VAPORS MAY BE SENSITIVE TO STATIC DISCHARGE - RESULTING IN FIRE OR EXPLOSION.
FIRE FIGHTING PROCEDURESWITHDRAW IMMEDIATELY IN CASE OF RISING SOUND FROM VENTING SAFETY DEVICE OR DISCOLORATION OF TANK DUE TO FIRE. KEEP STORAGE CONTAINERS COOL WITH WATER SPRAY. USE SELF-CONTAINED BREATHING APPARATUS (SCBA).
NFPA 704 RATING (0=LEAST, 4=EXTREME) : HEALTH=0, FIRE=1, REACTIVITY=0;
HEALTH HAZARD INFORMATION
SYMPTOMS OF EXPOSURE
ACUTE:
INHALED: HIGH CONCENTRATIONS OF VAPOR OR MIST MAY BE IRRITATING TO THE RESPIRATORY TRACT, INCLUDING NOSE AND THROAT. MAY CAUSE DIFFICULTY BREATHING.
SKIN: THIS MATERIAL MAY CAUSE SKIN IRRITATION. PROLONGED OR REPEATED CONTACT MAY CAUSE REDNESS, BURNING, AND DERMATITIS. CONTACT WITH HOT MATERIAL MAY CAUSE THERMAL BURNS.
EYES: CONTACT MAY CAUSE SLIGHT TO MODERATE IRRITATION, INCLUDING BURNING, TEARING, AND REDNESS. CONTACT WITH HOT MATERIAL MAY CAUSE THERMAL BURNS.
SWALLOWING (INGESTION): MAY CAUSE IRRITATION OF THE DIGESTIVE TRACT, NAUSEA AND VOMITING. ASPIRATION INTO THE LUNGS DURING INGESTION OR VOMITING MAY CAUSE MILD TO SEVERE PULMONARY INJURY AND POSSIBLY DEATH.
CHRONIC
PROLONGED AND/OR REPEATED SKIN CONTACT MAY CAUSE DRYING AND CRACKING OR DERMATITIS. EXPOSURE TO HIGH OIL MIST CONCENTRATIONS MAY LEAD TO OIL PNEUMONIA.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
CONTACT WITH SKIN MAY AGGRAVATE PRE-EXISTING DERMATITIS.
CARCINOGENICITY
NO INGREDIENTS OF THIS PRODUCT, PRESENT AT EQUAL TO OR GREATER THAN 0.1% OF THE PRODUCT, ARE LISTED BY OSHA, NTP OR IARC AS SUSPECTED CARCINOGENS.
EMERGENCY AND FIRST AID PROCEDURES
INHALED (BREATHING):
REMOVE TO FRESH AIR IMMEDIATELY. IF THERE IS DIFFICULTY BREATHING OR IF BREATHING HAS STOPPED, OXYGEN OR ARTIFICIAL RESPIRATION SHOULD BE ADMINISTERED BY QUALIFIED PERSONNEL. DO NOT LEAVE VICTIM UNATTENDED. SEEK IMMEDIATE MEDICAL ATTENTION IF NECESSARY.
SKIN:
REMOVE CONTAMINATED CLOTHING AND SHOES. DO NOT USE GASOLINE, THINNERS OR SOLVENTS TO REMOVE PRODUCT FROM SKIN. WIPE MATERIAL FROM SKIN AND WASH THOROUGHLY WITH SOAP AND WATER, AND IF NECESSARY A WATERLESS SKIN CLEANSER. CONSULT PHYSICIAN IF IRRITATION OR PAIN PERSISTS.
EYES:
FOR DIRECT CONTACT, FLUSH EYES WITH WATER FOR 15 MINUTES LIFTING UPPER AND LOWER LIDS OCCASIONALLY. CONSULT PHYSICIAN IF IRRITATION OR PAIN PERSISTS.
SWALLOWING (INGESTION):
DO NOT INDUCE VOMITING, BECAUSE MATERIAL CAN ENTER THE LUNGS AND CAUSE SEVERE DAMAGE. DRINK 4 TO 8 OUNCES OF WATER AND SEEK IMMEDIATE MEDICAL ATTENTION. IF VOMITING OCCURS, OR IF COMATOSE OR LETHARGIC, PLACE ON THE LEFT SIDE WITH THE HEAD DOWN - SEEK IMMEDIATE MEDICAL ATTENTION.
NOTE TO PHYSICIAN:
ADMINISTRATION OF GASTRIC LAVAGE, IF WARRANTED, SHOULD BE PERFORMED BY QUALIFIED MEDICAL PERSONNEL.
REACTIVITY DATA
STABILITY: STABLE, NOT REACTIVE WITH WATER.
INCOMPATIBILITY: MAY REACT WITH STRONG OXIDIZING AGENTS, SUCH AS; CHLORATES, NITRATES AND PEROXIDES. AVOID HEAT, SPARKS, AND FLAMES.
HAZARDOUS POLYMERIZATION: NOT KNOWN TO OCCUR UNDER NORMAL TEMPERATURES AND PRESSURES.
HAZARDOUS DECOMPOSITION: NO DECOMPOSITION PRODUCTS UNDER NORMAL PRODUCT CONDITIONS
SPECIAL PRECAUTIONS:
READ AND OBSERVE ALL PRECAUTIONS ON PRODUCT LABEL. DO NOT WELD, HEAT OR DRILL CONTAINER. RESIDUE MAY IGNITE WITH EXPLOSIVE VIOLENCE IF HEATED SUFFICIENTLY. CAUTION.DO NOT USE PRESSURE TO EMPTY DRUM OR EXPLOSION MAY RESULT.
SPILL, LEAK, AND DISPOSAL PROCEDURES
SPILL PROCEDURE
REMOVE ALL IGNITION SOURCES, AND AVOID BREATHING VAPORS. VENTILATE AREA IF CONFINED. CONTAIN AS A LIQUID FOR POSSIBLE RE-REFINING IF POSSIBLE BY DIKING AROUND OIL WITH A SUITABLE MATERIAL. IF NOT, ABSORB SPILLED LIQUID IN SAND OR INERT ABSORBENT. CONTAIN AWAY FROM SURFACE WATERS AND SEWERS. SHOVEL INTO CLOSABLE CONTAINER FOR DISPOSAL. CONTACT THE COAST GUARD NATIONAL RESPONSE CENTER (800) 424-8802 IF A SPILL OF ANY AMOUNT IS MADE INTO OR UPON U.S. NAVIGABLE WATERS, THE CONTIGUOUS ZONE, OR ADJOINING SHORELINES.
WASTE DISPOSAL METHODS
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, COUNTY, AND LOCAL REGULATIONS. CONTACT EVERGREEN OIL REGARDING RECYCLING OR DISPOSAL.
SPECIAL HANDLING INFORMATION VENTILATION AND HANDLING PRECAUTIONS
KEEP AWAY FORM HEAT, SPARKS AND FLAMES. AVOID CONTACT WITH EYES AND SKIN, AND AVOID BREATHING VAPORS OR MISTS. AVOID GENERATING OIL MISTS.
RESPIRATORY PROTECTION
WHEN AIRBORNE CONCENTRATIONS EXCEED RECOMMENDED EXPOSURE LIMITS, A MSHA/NIOSH APPROVED RESPIRATORY PROTECTIVE EQUIPMENT SHOULD BE WORN, SUCH AS AN ORGANIC VAPOR FILTER REPIRATOR. A SELF-CONTAINED BREATHING APPARATUS (SCBA) IS REQUIRED FOR FIRE EMERGENCIES.
EYE PROTECTION
WHERE THERE IS A LIKELIHOOD OF A SPILL OR SPLASH, WEAR CHEMICAL GOGGLES AND FACE SHIELD. CONTACT LENSES SHOULD NOT BE WORN.
HAND PROTECTION
USE LATEX, NEOPRENE, NITRILE RUBBER, OR EQUIVALENT GLOVES TO PREVENT CONTACT WITH THE SKIN. BARRIER CREAMS THAT ARE SPECIFIC FOR OIL-BASED MATERIALS ARE RECOMMENDED WHEN GLOVES ARE IMPRACTICAL.
OTHER PROTECTIVE CLOTHING
WEAR APPROPRIATE BOOTS, COVERALLS OR OTHER PROTECTIVE CLOTHING WHERE SPILLS AND SPLASHES ARE POSSIBLE. A SOURCE OF CLEAN WATER SHOULD BE AVAILABLE IN WORK AREAS FOR FLUSHING THE EYES AND SKIN IF NECESSARY.
STORAGE
STORE IN A COOL , DRY LOCATION. KEEP AWAY FORM INCOMPATIBLE MATERIALS. KEEP CONTAINER TIGHTLY CLOSED. EMPTY PRODUCT CONTAINERS MAY CONTAIN PRODUCT RESIDUE. DO NOT PRESSURIZE, CUT, HEAT, WELD, OR EXPOSE CONTAINERS TO FLAME OR OTHER SOURCES OF IGNITION.
TRANSPORTATION AND OTHER REGULATORY INFORMATION
DOT SHIPPING NAME: LIGHT NEUTRAL, MEDIUM NEUTRAL
DOT ID NUMBER: NOT APPLICABLE
DOT CLASS: NOT APPLICABLE
TSCA: COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY
SARA TITLE III:
PRODUCT DOES NOT CONTAIN TOXIC CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS AND RE AUTHORIZATION ACT OF 1986 AND 40 CFR PART 372.
SECTION 311 CATEGORIES:    IMMEDIATE (ACUTE) HEALTH EFFECT;  YES  
DELAYED (CHRONIC) HEALTH EFFECTS;                    NO
FIRE HAZARD;                                   NO
SUDDEN RELEASE OF   PRESSURE HAZARD;                                   NO
REACTIVITY HAZARD;                                   NO
THE INFORMATION CONTAINED IN THIS MSDS IS BELIEVED TO BE ACCURATE, AND REPRESENTS THE BEST INFORMATION CURRENTLY AVAILABLE TO EVERGREEN OIL. EVERGREEN OIL MAKES NO WARRANTY OF MERCHANTABILITY OR ANY OTHER WARRANTY, EXPRESS OR IMPLIED, WITH RESPECT TO SUCH INFORMATION, AND ASSUMES NO LIABILITY RESULTING FROM USE OF THIS INFORMATION. USERS OF THIS PRODUCT SHOULD MAKE THEIR OWN EVALUATION TO DETERMINE THE SUITABILITY OF THE PRODUCT FOR THEIR PARTICULAR PURPOSES, AND SHOULD ESTABLISH SAFE HANDLING PROCEDURES.
PREPARED BY: LAB MSDS COORDINATOR
REVISED: December 20, 2004         SUPERSEDES: July 01, 2003

Keywords: Lubricating Oil, Oil

Other products and services from Evergreen Oil

09-12-2011

Re-Refined Oil Products And Hazardous Waste Disposal California Trusts From Evergreen Oil - oil products

If incoming feedstock is found to contain non-lubricant contaminants, such as highly chlorinated solvents, it is excluded from the processing stream and transported to other permitted hazardous waste facilities for proper disposal. Our facility in Newark, California produces top quality neutral base lube stocks, with exceptional color and stability.


09-12-2011

Re-Refined Oil Products And Hazardous Waste Disposal California Trusts From Evergreen Oil - hazardous waste facilities

The plant can accept oil containing up to 10% water, less than 5 parts per million polychlorinated biphenyls, and 1,000 parts per million total organic halogens. Our permit allows for consolidation of non-volatile solid waste, non-RCRA waste waters, oil and antifreeze, and small quantity packages of laboratory chemicals.