Service Department - Heating - aircond

By: Hvac Oracle  09-12-2011
Keywords: Compressor

A properly maintain air conditioner will use less energy, provide greater cooling and provide 20+ years or service with little or no break downs. This equipment uses compressed refrigerants under high pressure, line voltage and low voltage control systems and mechanical system. Only personnel familiar with this type of equipment should perform repairs. General maintenance can be performed by anyone with basic mechanical skills. Before starting any compressor, the controls must be power for 24 hours. This is to allow the compressor heaters to boil off any refrigerant in the oil. Failure to follow this can result in permanent damage or failure of the compressor. In case you did startup the compressor right away, that loud clanging noise was the compressor piston trying to blow a hold in the top of the compressor. Do not attempt to work on any piece of equipment, or remove any panel when the unit is powered. There maybe be exposed electrical connections or moving parts the can cause serious injury or death. Spilt systems using an indoor and outdoor condensing unit have separate power supply. Make sure each is shut off before servicing.

Keywords: Compressor

Other products and services from Hvac Oracle

09-12-2011

Service Department - Heating - Refrigeration

The compressor does not start on smaller fractional horsepower refrigeration units. Product is too warm while the compressor and fans are running. Compressor frequent start and stops & cooler too warm. Not enoungh cooling due to a dirty condenser. What basic Maintenace can I do myself.


09-12-2011

Service Department - Heating - ventilation

When the air inside a commerical building feels stale or stuffy, check the economizer for proper operation. In all commerical building, the supply air fan should run continously when the building is occupied. The miniumum position is set by the adjsutable slider control on the left side. The damper in the economizer should be be set to provied 10% to 20% fresh air. This allows air to be drawn in from the outside through the economizer.


09-12-2011

Service Department - Heating - service

After you complete payment, you will receive 15 minutes of basic trouble shooting tips to address problems with Heating, Air conditioning, Refrigeration, Plumbing, and control problems. Whether it is residential or commerial repair, guiding maintenance staff or communicating with contractors and engineers, we would like to help.